Steering Linkage and Components Removal?

The complete details procedure.

The Procedure mentioned Covers Dodge Ram 1500, 2500, 3500, 2WD & 4WD. Its For 2001 – 2005 Year Models.

The Ram steering linkage consists of a pitman arm, drag link or center link, tie rod, and on independent front suspension models, idler arms. Steering linkages vary in detail depending on front suspension (link/coil or independent), and service rating (LD or HD). Service procedures apply to all types, however. Note the following points:

• Pullers are required to separate the components.
• If any components are replaced or serviced, an alignment must be performed.
• Be sure to matchmark all components so that they can be reinstalled in their original positions.
• Components attached with a nut and cotter pin must be torqued to specification. Then, if the slot in the nut does not line up with the cotter pin hole, tighten the nut until alignment is achieved. Never loosen the nut to insert the cotter pin.
• Replace any torn seals. When assembling the steering linkage, be sure to obey all torque specifications for your model. Use new cotter pins.
• Lubricate all components with a good grade of chassis grease. 

See the Helpful Diagram Shown below:---

Fig. Major components of the steering linkage are similar for all models-HD link/coil shown

Major components of the steering linkage are similar for all models-HD link/coil shown

Fig. Steering linkage components must be separated with pullers

Steering linkage components must be separated with pullers

Fig. Removing the pitman arm with a puller

ITS RECOMMENDED TO VIEW THIS HELP LINKS:---

How to replace Tie Rod Ends on 2005 Dodge Ram?

http://fordrepairhelp.blogspot.in/2012/04/how-to-replace-tie-rod-ends-on-2005.html

Tie Rod Ends Removal Diagrams For Dodge Ram?

http://fordrepairhelp.blogspot.in/2012/04/how-to-replace-tie-rod-ends-on-2005.html

After Power Steering Pump Lines are Disconnected?

http://fordrepairhelp.blogspot.in/2012/04/after-power-steering-pump-lines-are.html

After Servicing Power Steering?

http://fordrepairhelp.blogspot.in/2012/04/after-servicing-power-steering.html

Replacing Pitman on 2005 Dodge RAM?

http://fordrepairhelp.blogspot.in/2012/04/link-coil-suspension-details-for-2005.html

Inner Tie Rod, Idler & Pitman Arms Replacing on 2005 Dodge RAM?

http://fordrepairhelp.blogspot.in/2012/04/inner-tie-rod-idler-pitman-arms.html

2005 Dodge RAM steering linkage: Replacing independent front suspension?

http://fordrepairhelp.blogspot.in/2012/04/2005-dodge-ram-steering-linkage.html

These details will help.

Thanks.           

FOR MORE HELP GO TO: ---

Car repair guide?

http://technoanswers.blogspot.in/2012/03/car-repair-guide.html